Skip to content
Research Article Open access CC BY 4.0

Experimental and Analytical Investigations of Innovative Composite Materials Using GFRP and Iron Slag for Railway Sleepers

Ali S. Shanour, Ahmed Abdelmoamen Khalil, Hany Sobhy Riad, Heba Mahmoud Bakry

Journal of Engineering Research and Reports · pp. 25–42 · Published 3 Jun 2020

10.9734/jerr/2020/v13i217098

Abstract

This paper presents further results of experimental testing and analytical investigation on the mechanical properties of fiber composite sleeper in order to evaluate its strength and behavior. Recycled high density polyethylene, iron slag, calcium carbonate, styrene and polyester resin were used with different percentages for manufacturing the proposed composite sleepers. Adding glass fiber ropes and woven laminates as a reinforcement to enhance the flexural capacity of the proposed composite material. Negative bending at center and positive rail seat compression were performed on full scale sleeper. Two full scale sleepers were proof loaded up to 72, 82 KN under negative bending test without any generated cracks. Also, under positive rail seat compression test, first crack occurred at load ranged from 170, 195 KN and failure load happened at load 270, 250 KN. That's mean that the strength of sleeper ranged from 36.39 to 39.30 MPa. This result showed  that  the  proposed  composite  material  of  sleeper  has  sufficient  strength  to  hold mechanical connections. Nonlinear finite element analysis (NLFEA) predicted the behavior up to failure load of the proposed composite sleeper reasonably well. This confirms that the behavior and failure modes of composite sleeper can be well predicted by simplified analysis procedures. Comparison of proposed composite with commercially available composite and timber sleepers' behavior was presented. It is found that proposed composite sleeper performance is near or similar to that of timber and better than that of commercially available composite sleepers. It is concluded that the proposed composite sleeper can be effectively used for timber sleeper replacement.

GFRP composite material iron slag-railway sleepers NLFEA

References (3)

  1. 1 EVALUATION OF CONVENTIONAL METHODS IN ANALYSIS AND DESIGN OF RAILWAY TRACK SYSTEM
  2. 2 Mechanical Testing of Innovated Composite Polymer Material for using in Manufacture of Railway Sleepers [DOI]
  3. 3 Natural rubber composites for railway sleepers : a feasibility study

Cited by 10

Comparative analysis of resistance characteristics of composite sleeper and concrete sleeper in ballast bed

Jianxing Liu, Rong Chen, Zhiye Liu · Construction and Building Materials · 2021

Suitability of recycled materials as a composite sleeper: A scoping review

Md Eaysir Arafat, Faris Imam · Materials Today: Proceedings · 2022

Physio-chemical analysis and characteristics of nanoclay hybrid polyamide biocomposite

Ahmad Musa Mukaddas, Farah Nora Aznieta Abdul Aziz, Khalina Abdan · Journal of Materials Science: Composites · 2025

Showing 4 of 10 known citations — external sources report more than can currently be individually listed.

Article metrics

Real usage data collected on this platform.

6

Page views

0

PDF downloads

0

Outbound clicks

10

Citations

Views over time

Views by country

Approximate, from request IP at view time — not citizenship or institution. Countries with fewer than 5 views are grouped as "Other".

Traffic sources

Referring site, by host.

Views and downloads exclude known bots/crawlers. Citations combines this platform's own DOI-resolved index with each external source's own reported total — see Cited by above for individually listed citing works. Last refreshed 0 seconds ago.